Effects of ractopamine hydrochloride on the growth performance and carcass characteristics of heavy-weight finishing pigs sent for slaughter using a 3-phase marketing strategy.

A total of 2,158 crossbred pigs was used to evaluate the effects of feeding 7.4 mg/kg ractopamine hydrochloride (RAC) on the growth performance and carcass characteristics of heavy-weight finishing pigs sent to slaughter using a 3-phase marketing strategy. The study was performed from 121.0 ± 4.28 kg to 144.5 ± 4.73 BW using a randomized complete block design (blocking factor was d of start on test) with 2 treatments (0 vs. 7.4 mg/kg RAC). Pigs were housed in a commercial wean-to-finish facility in groups of approximately 25 (44 groups/treatment), with ad libitum access to feed and water throughout the study, and pen weights of pigs were recorded at the start (d 0), and on d 7, 21, and 35 of study. Pigs were sent for slaughter according to the following marketing strategy: 1) after 7 d on RAC, the heaviest 16% of each pen was sent for slaughter (Phase 1), 2) after 21 d on RAC, the next 40% of each pen was sent for slaughter (Phase 2), and 3) after 35 d on RAC, the remaining 44% of each pen was sent for slaughter (Phase 3). Pigs were selected for slaughter by visual appraisal and shipped to a commercial facility where standard carcass measurements (HCW, LM depth, and backfat depth) were measured. Overall, feeding RAC increased (P < 0.001) ADG (18.8%) and G:F (23.7%) compared to the control, but lowered (P < 0.001) ADFI (3.3%). In addition, feeding RAC increased (P < 0.001) HCW (3.9 kg), carcass yield (0.7% units), LM depth (5.0%), and predicted lean content (1.0% units), and reduced backfat depth (6.3% lower) compared to controls. With each subsequent phase of marketing, the magnitude of improvements in response to feeding RAC decreased for ADG (43.1, 20.9, and -3.1% for Phase 1, 2, and 3, respectively) and G:F (37.5, 25.8, and 6.4% for Phase 1, 2, and 3, respectively); however, improvements in HCW (1.6, 4.5, and 4.2 kg for Phase 1, 2, and 3, respectively), carcass yield (0.2, 0.6, and 0.9% units for Phase 1, 2, and 3, respectively), LM depth (2.3, 5.7, and 5.2% for Phase 1, 2, and 3, respectively), and predicted lean content (0.2, 1.0, and 1.3% units for Phase 1, 2, and 3, respectively) generally increased from feeding RAC. These results suggest that while improvements in growth performance from feeding RAC will generally decline after 21 d of feeding, improvements in carcass traits, particularly carcass yield and lean content, will continue with feeding RAC until d 35.

Effect of narasin (Skycis) or zinc bacitracin (Albac) inclusion on the growth performance and carcass characteristics of finishing pigs sent for slaughter using a 3-phase marketing strategy.

The objective of this study was to evaluate the effect of dietary inclusion of narasin or zinc bacitracin on the growth performance and carcass characteristics of finishing pigs sent for slaughter using a 3-phase marketing strategy. The study used 2,219 crossbred pigs in a randomized complete block design (blocking factor = start date) with 3 dietary treatments: 1) Control (no feed additive), 2) 15 mg/kg narasin (Skycis, Elanco Animal Health, Greenfield, IN), and 3) 28 mg/kg zinc bacitracin (Albac, Zoetis, Parsippany, NJ). Pigs were housed in single-sex pens of 25 pigs in a commercial wean-to-finish facility and there were 30 pen-replicates of each dietary treatment. All pigs were weighed as a group (i.e., pen) on d 0 (start of experimental feeding period), 77, 91, and 105 (end) of study. Pigs had ad libitum access to feed and water throughout the study period; all feed additions to the feeder were recorded. Pigs were sent for slaughter according to the following marketing strategy: 1) after 77 d on study, the heaviest 20% of each pen was sent for slaughter (Phase 1), 2) after 91 d on study, the next heaviest 48% of each pen were sent for slaughter (Phase 2), and 3) after 105 d on study, the remaining 32% of each pen was sent for slaughter (Phase 3). Pigs within each pen were selected for slaughter by visual appraisal of weight and shipped to a commercial slaughter facility where standard carcass measurements (HCW, LM depth, and backfat depth) were measured. Feeding narasin increased (P < 0.05) final live BW (1.3 kg) and overall ADG (1.1%) compared to the other treatments, which were similar (P > 0.05). Dietary treatment did not impact (P > 0.05) overall G:F. Feeding narasin increased (P < 0.05) HCW (1.4 kg) and carcass yield (0.3% units) compared to the other dietary treatments, which were similar (P > 0.05) for these traits. Overall, these results demonstrate that narasin-fed pigs had improved overall growth rate, HCW, and carcass yield compared to controls or pigs fed zinc bacitracin.

Evaluation of the optimal standardized ileal digestible tryptophan:lysine ratio in lactating sow diets.

Three hundred and fifteen primiparous and multiparous sows were evaluated in a study to determine the effect of standardized ileal digestible (SID) Trp:Lys ratio in lactating sow diets. Camborough sows (PIC USA, Hendersonville, TN) ranging from first parity to eighth parity were blocked by parity and randomly allotted to 1 of 4 experimental diets containing different levels of added L-Trp (0.006, 0.026, 0.045, and 0.064%, respectively) while soybean meal, 30% corn dried distiller's grain with solubles (DDGS), and L-Lys levels were held constant. The SID Lys level for the rations was 0.95% so that the SID Trp:Lys ratios were formulated to be 14, 16, 18, and 20%, respectively. All diets were formulated to have 3.2 Mcal ME/kg and to contain vitamins and minerals that exceeded NRC (1998) recommendations. Sows were fed twice a day with a Howema computerized feed system and were allowed a maximum intake (5.9 kg/d). Average daily feed intake had a tendency to be quadratically improved when the SID ratio was increased (5.11, 5.28, 5.24, 5.21 kg/d, P = 0.09). In addition, sow wean to estrus (6.71, 5.53, 5.58, 6.33, P < 0.02) was quadratically improved as SID Trp:Lys ratio increased. Percent of sows bred by 10 d (84.39, 90.82, 90.28, 90.61) was not linearly (P = 0.25) or quadratically (P = 0.40) improved. There was no difference in litter gain (2.44, 2.52, 2.60, 2.57 kg/d, P = 0.16). Based on a broken-line quadratic model, when sows are fed 30% DDGS, the SID Trp:Lys ratio of 17.6 is required for optimal sow average daily feed intake and 17.2 for wean to estrus interval.

Ham and belly processing characteristics of immunological castrated barrows (Improvest) fed ractopamine hydrochloride (Paylean).

Effects of sex class (physically castrated, PC or immunologically castrated, IC) and diet (0 or 5mg/kg ractopamine hydrochloride, RAC) on characteristics of ham and bellies were determined from pigs slaughtered in three groups with similar ending live weights. One carcass per pen per marketing group (n=8) was selected to evaluate further processing characteristics. Data were analyzed as a 2×2 factorial design with a split plot in time and fixed effects of sex, diet, marketing group, and their interactions. IC fresh bellies were thinner (P<0.01) and softer (P<0.01) than PC bellies. IC hams and bellies were leaner (P<0.05) than those from PC pigs. RAC feeding did not affect (P>0.05) fresh ham or belly characteristics but decreased (P<0.01) fat in cured PC bellies. Marketing group affected (P<0.05) fresh quality, processing characteristics, and composition of hams and bellies. Immunological castration and RAC produced leaner finished products but did not alter processing yield of hams or bacon.

The feeding of dried distillers' grains with solubles to lactating sows.

Three experiments were conducted to evaluate the feeding of dried distillers' grains with solubles (DDGS) in sow lactation diets. In Exp. 1, 168 multiparous sows (PIC, Camborough 22) were fed a 10% DDGS diet throughout gestation. Sows were randomly allotted to 1 of 4 corn-soybean meal lactation diets formulated to contain different levels of DDGS (0, 10, 20, and 30%, respectively). All diets were formulated to be isocaloric (3.46 Mcal ME/kg) and all other nutrients exceeded NRC (1998) nutrient recommendations. Sow ADFI was not different ( > 0.10) as DDGS level increased. Increasing DDGS resulted in a linear ( < 0.03) increase in sow weight gain (7.5, 11.3, 20.3, and 17.2 kg, respectively) and a reduction in wean-to-first-service interval (7.1, 5.2, 5.0, and 4.9 d, respectively). Increasing DDGS did not affect subsequent total born per litter (13.7, 12.8, 13.3, and 12.3, respectively; > 0.10). In Exp. 2 and 3, lactation diets consisted of corn and 20, 30, 40, or 50% DDGS. Diets were formulated at 3.25 Mcal ME/kg, 1.05% standardized ileal digestible lysine, and all other nutrients to exceed NRC (1998) nutrient recommendations. In both experiments, sows (PIC, Camborough) were fed 40% DDGS in gestation and allocated to a randomized complete block based on the parity of the sow at the time of entry into the farrowing house. In Exp. 2, 256 gilts and multiparous sows were fed the randomly assigned diets. As DDGS inclusion increased, sow feed intake (6.2, 6.2, 6.0, and 5.9 kg/d, respectively) and sow weight gain (10.5, 10.3, 8.2, and 6.2 kg, respectively) tended to linearly decrease ( < 0.06). Sow wean to estrus differed between 20 and 30% DDGS inclusion (4.9 vs. 6.9 d; < 0.01). Litter gain was not different (2.55, 2.53, 2.51, and 2.59 kg/d, respectively; > 0.10) as DDGS inclusion increased. In Exp. 3, 98 multiparous sows were randomly allotted to 1 of the 4 experimental diets during the summer months. Sow feed intake, sow weight gain, and litter gain were not different ( > 0.10) between treatments. The data suggest that feeding high levels of DDGS of 40 to 50% may reduce sow feed intake and litter performance. These results demonstrate that feeding up to 30% DDGS in lactation diets can be done without adversely influencing sow or litter performance.

Effects of narasin (Skycis) on live performance and carcass traits of finishing pigs sold in a three-phase marketing system.

The objective was to evaluate the effect of feeding narasin (Skycis; Elanco Animal Health, Greenfield, IN) on growth performance and carcass characteristics of finishing pigs sold in a 3-phase marketing system. Pigs ( = 1,232) were housed in 56 single-sex pens (22 pigs/pen) divided into 2 even blocks based on initiation of treatment. Each treatment × sex combination was replicated 14 times. Pigs were fed either 0 mg/kg narasin (control) or 15 mg/kg narasin for up to 85 d of finishing (initiated at an average of 52.95 kg BW). In each pen, 18% (4 pigs per pen) of pigs were sold in the first marketing group (Day 64 of dietary treatment), 50% (11 of the original 22) were sold in the second marketing group (Day 78), and 32% (the remaining 7 pigs) were sold in the third marketing group (Day 85). Data were analyzed as a randomized complete block design with pen as the experimental unit. The model included the fixed effects of diet, sex, and their interaction. Block and replicate nested within block were random variables. Carcass data from pigs in marketing group 3 of block 2 was not collected due to inclement weather. Narasin had no effect on growth performance traits ( ≥ 0.15) in phases 1 (Days 1-28) or 2 (Days 29-56), regardless of sex. Barrows fed narasin had a 2.0% greater overall (Day 0-85) ADG than barrows fed the control diet ( < 0.01), but ADG of gilts was not different due to diet ( = 0.69). Regardless of sex, narasin improved ( = 0.03) feed efficiency (G:F) by 1.3% throughout the 85-d feeding period. There were no effects ( ≥ 0.21) of narasin on carcass composition in marketing groups 1 and 2. Narasin-fed barrows in marketing group 3 had 0.9 percentage units lower ( < 0.01) estimated carcass lean compared with barrows fed control diets (51.0 vs. 52.0%); no difference existed in gilts ( = 0.21). This is likely due to narasin-fed barrows of marketing group 3 tending ( = 0.06) to have 7.7% greater fat depth than control barrows of marketing group 3. Pooled effects (across all 3 marketing groups) of feeding narasin tended ( = 0.08) to reduce loin depth by 1.1% (60.00 vs. 60.66 mm), but there were no effects on fat depth ( = 0.24) or estimated carcass lean ( = 0.11). Overall, narasin can be used during the last 85 d of feeding to increase feed efficiency of barrows and gilts with minimal impact on carcass composition.

Effects of feeding ractopamine hydrochloride (Paylean) to physical and immunological castrates (Improvest) in a commercial setting on carcass cutting yields and loin quality.

Effects of feeding ractopamine (RAC; 5 mg/kg) to physically castrated (PC) and immunologically castrated (IC) pigs on carcass characteristics, cutting yields, and loin quality were evaluated using 285 carcasses. Male pigs were randomly assigned to sex treatments (PC and IC) at birth and fed the same nursery diets before allotment into 32 pens with 22 pigs per pen in a grow-finish barn. Pigs in the PC group were physically castrated at approximately 5 d of age, and pigs in the IC group were administered Improvest at 11 and 18 wk of age. Diet treatments (control or RAC) were initiated on study d 87. Pigs were marketed at 12 d (4.5 wk post-second Improvest dose), 19 d (5.5 wk post-second Improvest dose), and 33 d (7.5 wk post-second Improvest dose) following the start of final diet treatments. Three carcasses per pen were selected for evaluation of cutting yields and loin quality. Data were analyzed using PROC MIXED in SAS with fixed effects of sex, diet, market group, and their interaction; carcass (N = 285) was the experimental unit. Carcasses from RAC-fed pigs were heavier (P < 0.01) and had deeper (P = 0.02) loins than control-fed carcasses. Carcasses from IC pigs were similar (P = 0.22) in weight but had less (P < 0.01) fat and shallower (P = 0.02) loins when compared to PC carcasses. There were differences (P < 0.05) among market groups for carcass weights, fat depths, loin depths, and estimated carcass leanness. For cutting yields, RAC-fed carcasses had greater (P ≤ 0.03) bone-in lean and total carcass cutting yields than control-fed carcasses while there were no differences (P > 0.05) between RAC-fed and control-fed carcasses when evaluating LM color, marbling, firmness, pH, drip loss, and tenderness. Carcasses from IC pigs had greater (P < 0.05) boneless lean yields, bone-in lean yields, and total carcass cutting yields than PC carcasses. There were minimal differences (P < 0.05) in LM marbling, firmness, composition, and tenderness between PC and IC pigs. There was an interaction (P = 0.03) between sex and diet for LM composition. Control-fed PC loins had more (P < 0.01) lipid than all other treatment combinations. Market group had effects (P < 0.05) on carcass cutting yields, LM color, marbling and firmness scores, pH, purge loss, composition, and tenderness. The results from this study indicated RAC and immunological castration were additive in terms of improving carcass cutting yields while having minimal effects on pork quality.

Effects of feeding ractopamine hydrochloride (Paylean) to physical and immunological castrates (Improvest) in a commercial setting on growth performance and carcass characteristics.

Growth performance and carcass characteristics of physically castrated (PC) and immunologically castrated (IC) pigs fed ractopamine hydrochloride (RAC; 5 mg/kg) were evaluated in 64 pens of 22 pigs each. Male pigs were randomly assigned to castration method at birth. Pigs in the PC group were physically castrated at 5 d of age while IC pigs were administered Improvest at 11 and 18 wk of age. Pigs entered the grow-finish barn at approximately 9 wk of age (d 0). Dietary treatments (control or RAC) were initiated on d 87. Final treatment arrangement was a 2 × 2 factorial of castration method and diet. Data were analyzed using a mixed model with fixed effects of castration method, diet, market group, and all 2- and 3-way interactions. Pen was the experimental unit. From d 0 to 65, IC pigs had 11.2% greater (P < 0.01) G:F and 11.6% less (P < 0.01) ADFI than PC pigs, but ADG was increased 1.0% in PC pigs compared with IC pigs (P < 0.01). From d 65 to 87, IC pigs had 7.9% greater (P < 0.01) ADG and 12.1% greater (P < 0.01) G:F than PC pigs while having similar (P = 0.16) ADFI. At the initiation of diet (RAC) treatments, BW of all treatments were similar (P ≥ 0.32). From d 87 to 120 (RAC feeding period), IC pigs had 10.0% greater (P < 0.01) ADG and 10.5% greater (P < 0.01) ADFI than PC pigs while having similar (P = 0.64) G:F. Feeding RAC increased (P < 0.01) ADG by 16.9% and G:F by 17.9% while having no effect (P = 0.42) on ADFI from d 87 to 120. There were no significant interactions between castration method and diet on growth performance from d 87 to 120. For the entire study (d 0-120), IC pigs had 2.6% greater (P < 0.01) ADG, 4.6% less (P < 0.01) ADFI, and 7.3% greater (P < 0.01) G:F than PC pigs. Averaged over market groups, IC pigs were 2.5 kg heavier (P < 0.01) and had similar (P = 0.10) carcass weights and 1.8 percentage units less (P < 0.01) dressing yields than PC pigs. Additionally, IC pigs had 1.3 mm less (P < 0.01) fat and 1.7 mm less (P < 0.01) loin depth than PC pigs. Pigs fed RAC were 2.9 kg heavier (P < 0.01) and had 2.3 kg heavier (P < 0.01) carcasses and 2.2 mm deeper (P < 0.01) loins but similar (P = 0.21) dressing yields and tended (P < 0.10) to have 0.4 mm less fat than control-fed pigs when averaged over market groups. Group 3 pigs were the heaviest (P < 0.01) at slaughter and had the heaviest (P < 0.01) carcasses, greatest (P < 0.01) dressing yields, and the most (P < 0.01) carcass fat of all market groups. Overall, immunological castration and RAC were additive in terms of improving growth performance and carcass characteristics.

Impact of ractopamine hydrochloride on growth, efficiency, and carcass traits of finishing pigs in a three-phase marketing strategy.

The objectives were to determine the effects of ractopamine hydrochloride (RAC) in a 3-phase marketing strategy. One thousand seven hundred forty pigs were used in 80 single-sex pens in 2 blocks. Each pen housed approximately 22 pigs. Sixteen percent of the total population of pigs was sold during the first marketing period, 18% was sold during the second marketing period, and the remaining 66% was sold during the third marketing period. Data were analyzed as a randomized complete block design of 2 treatments. Pigs in the second marketing group had greater growth performance indicators than pigs in the first marketing group. Over the entire feeding period, pigs fed RAC were 2.73 kg heavier (P < 0.0001), had 0.11 kg/d greater (P < 0.0001) ADG, and had 0.04 greater (P < 0.0001) G:F than pigs not fed RAC. Hot carcass weights were 3.3% greater (P < 0.0001), carcass yields were 0.68 (% units) greater (P < 0.0001), fat depth was 7.2% less (P < 0.0001), loin depth was 5.6% greater (P < 0.0001), and estimated carcass lean was 0.97% units greater (P < 0.0001) in RAC-fed pigs when compared with pigs not fed RAC. By the end of the first marketing period carcasses from pigs fed RAC (89.73 kg) were 2.1% heavier (P = 0.04) and gained 0.19 kg/d more (P = 0.03) carcass weight than carcasses from pigs not fed RAC (87.89 kg). By the end of the second marketing period carcasses from pigs fed RAC (99.00 kg) were 3.1% heavier (P < 0.001) and gained 0.14 kg/d more (P < 0.001) carcass weight than carcasses from pigs not fed RAC (96.02 kg). By the end of the third marketing period carcasses from pigs fed RAC (102.75 kg) were 3.7% heavier (P < 0.0001) and gained 0.10 kg/d more (P < 0.0001) carcass weight than carcasses from pigs not fed RAC (99.06 kg). Although carcass gain per day decreased with extended RAC feeding duration, HCW advantages continued to increase as feeding duration was increased from 7 d to 35 d. Growth benefits were evident during the initial marketing period, but as duration increased differences diminished. Therefore, RAC can provide the expected growth performance benefits when included in the diet for up to 21 d, but HCW advantages continue to increase throughout the entire 35 d feeding period. Even though carcass benefits were not as evident in pigs sold during the first marketing period, advantages (particularly HCW) continued to increase with each marketing period.

Effects of dietary soybean oil on pig growth performance, retention of protein, lipids, and energy, and the net energy of corn in diets fed to growing or finishing pigs.

The objectives of this experiment were 1) to determine if dietary soybean oil (SBO) affects the NE of corn when fed to growing or finishing pigs, 2) to determine if possible effects of dietary SBO on the NE of corn differ between growing and finishing pigs, and 3) to determine effects of SBO on pig growth performance and retention of energy, protein, and lipids. Forty-eight growing (initial BW: 27.3 ± 2.5 kg) and 48 finishing (initial BW: 86.0 ± 3.0 kg) barrows were used, and within each stage of growth, pigs were allotted to 1 of 6 groups. Two groups at each stage of growth served as an initial slaughter group. The remaining 4 groups were randomly assigned to 4 dietary treatments and pigs in these groups were harvested at the conclusion of the experiment. A low-lipid basal diet containing corn, soybean meal, and no added SBO and a high-lipid basal diet containing corn, soybean meal, and 8% SBO were formulated at each stage of growth. Two additional diets at each stage of growth were formulated by mixing 25% corn and 75% of the low-lipid basal diet or 25% corn and 75% of the high-lipid basal diet. Results indicated that addition of SBO had no effects on growth performance, carcass composition, or retention of energy, protein, and lipids but increased (P < 0.05) apparent total tract digestibility of acid hydrolyzed ether extract and GE. Addition of SBO also increased (P < 0.05) DE and NE of diets, but had no effect on the DE and NE of corn. Finishing pigs had greater (P < 0.05) growth performance and retention of energy, protein, and lipids than growing pigs. A greater (P < 0.05) DE and NE of diets was observed for finishing pigs than for growing pigs and the DE and NE of corn was also greater (P < 0.05) for finishing pigs than for growing pigs. In conclusion, addition of SBO increases the DE and NE of diets but has no impact on the DE and NE of corn. Diets fed to finishing pigs have greater DE and NE values than diets fed to growing pigs and the DE and NE of corn are greater for finishing pigs than for growing pigs.

Effects of dietary soybean hulls and wheat middlings on body composition, nutrient and energy retention, and the net energy of diets and ingredients fed to growing and finishing pigs.

The objectives of this experiment were 1) to determine the effect of dietary soybean hulls (SBH) and wheat middlings (WM) on body composition, nutrient and energy retention, and the NE of diets and ingredients fed to growing or finishing pigs and 2) to determine if finishing pigs use the energy in SBH and WM more efficiently than growing pigs. Forty growing barrows (initial BW: 25.4 ± 0.7 kg) and 40 finishing barrows (initial BW: 84.8 ± 0.9 kg) were randomly allotted to 5 groups within each stage of growth. Two groups at each stage of growth served as the initial slaughter group. The remaining pigs were randomly assigned to 3 dietary treatments and harvested at the conclusion of the experiment. The basal diet was based on corn and soybean meal and was formulated to be adequate in all nutrients. Two additional diets were formulated by mixing 70% of the basal diet and 30% SBH or 30% WM. In the growing phase, ADG, G:F, and retention of lipids were greater (P < 0.05) for pigs fed the basal diet than for pigs fed the diets containing SBH or WM. Retention of energy was also greater (P < 0.05) for pigs fed the basal diet than for pigs fed the SBH. In the finishing phase, pigs fed the SBH diet tended (P = 0.10) to have a greater ADG than pigs fed the WM diet, and energy retention was greater (P < 0.05) for pigs fed the basal diet than for pigs fed the WM diet. The NE of the basal diet fed to growing pigs was greater (P < 0.01) than the NE of the diets containing SBH or WM, and there was a tendency for a greater (P = 0.05) NE of the basal diet than of the other diets when fed to finishing pigs. The NE of SBH did not differ from the NE of WM in either growing or finishing pigs, and there was no interaction between ingredients and stage of growth on the NE of diets or ingredients. The NE of diets for growing pigs (1,668 kcal/kg) was not different from the NE of diets for finishing pigs (1,823 kcal/kg), and the NE of the diets containing SBH (1,688 kcal/kg) was not different from the NE of the diets containing WM (1,803 kcal/kg). Likewise, the NE of SBH (603 kcal/kg) did not differ from the NE of WM (987 kcal/kg). In conclusion, inclusion of 30% SBH or WM decreases the performance and nutrient retention in growing pigs but has little impact on finishing pigs. The NE of the diets decreases with the inclusion of SBH and WM, but the NE of diets and ingredients is not affected by the BW of pigs. The NE of SBH is not different from the NE of WM.

Effect of corn dried distillers grains with solubles, conjugated linoleic acid, and ractopamine (paylean) on growth performance and fat characteristics of late finishing pigs.

An experiment was performed to evaluate effects of dietary ractopamine, CLA, and corn distillers dried grains with solubles (DDGS) on growth and carcass and fat quality of finishing pigs. This study was conducted as a split-split plot arrangement in a generalized randomized block design. In total 1,102 crossbred barrows and gilts (initial BW = 100.4 kg, SD = 3.7 kg; pic 337 × c22) were randomly assigned to 1 of 8 dietary treatments that consisted of 2 diet sources [corn-soybean meal (corn-soy) and corn-soy + 20% DDGS], 2 levels of ractopamine (0 and 7.4 mg/kg), and 2 levels of CLA (0% and 0.6%). The pen was the experimental unit, with 6 replications per treatment for a total of 48 pens with 23 pigs per pen. Pigs had ad libitum access to water and feed during the 27-d experimental period. Ractopamine addition improved (p < 0.05) ADG and G:F over the control group. Furthermore, carcass weight, carcass yield, loin depth, and lean percentage were increased and back fat depth was decreased (p < 0.05) by feeding ractopamine. Feeding CLA resulted in improved (p < 0.05) ADG and G:F and increased lean percentage but reduced carcass yield (p < 0.05). The inclusion of DDGS did not affect ADG, adfi, or g:f but reduced (p < 0.05) carcass dressing percent. An increase (p < 0.05) in the concentration of pufa was observed with inclusion of DDGS, ractopamine, and CLA. Iodine value (iv) increased (p < 0.001) in both belly and jowl samples by feeding DDGS and ractopamine, whereas a decrease (p < 0.01) was observed when CLA was included in the diets. The fatty acid profiles of belly and jowl fat samples were affected (p < 0.05) by diet source × ractopamine, indicating that effects of dietary ractopamine depend on the fatty acid profile of the diet. These results indicate that feeding ractopamine and CLA could improve growth and carcass measures and that CLA was effective in diminishing some of the negative effects, especially on IV, caused by DDGS.

Evaluation of standardized ileal digestible lysine requirement of nursery pigs from seven to fourteen kilograms.

Four experiments were conducted to determine the standardized ileal digestible (SID) Lys requirement of pigs (Sus scrofa) from 7 to 14 kg. In Exp. 1, 294 pigs (6.8 kg BW) were used in a 28-d growth trial with 7 pigs per pen and 7 pens per treatment. Treatment diets were fed from d 0 to 14, and a common diet was fed from d 14 to 28. The 6 SID Lys levels tested were 1.15, 1.23, 1.30, 1.38, 1.45, and 1.53%. The diets were corn- and soybean-meal [Zea mays L. and Glycine max (L.) Merr.] based, with 10% spray-dried whey, 4.5% fish meal, and contained 3.37 Mcal of ME/kg. From d 0 to 14, ADG increased (quadratic, P < 0.001) as SID Lys increased from 1.15 to 1.30% with no further increase at greater levels. Gain:feed increased (linear, P < 0.001) with increasing SID Lys. Experiments 2 to 4 were 14-d growth trials with diets containing 1.22, 1.32, 1.42, 1.52, or 1.62% SID Lys. Diets were corn- and soybean-meal based with 3.45 Mcal of ME/kg. Soybean meal and lactose were constant in all diets at 30 and 7% of the diet, respectively. In Exp. 2, 840 pigs (7.6 kg BW) were used, with 24 pigs per pen and 7 pens per treatment. Increasing SID Lys from 1.22 to 1.42% increased (quadratic, P < 0.01) ADG and G:F with no further improvement observed in pigs fed the 1.52 or 1.62% SID Lys diets during d 0 to 14. In Exp. 3, 1,260 pigs (8.5 kg BW) were used with 42 pigs per feeder (2 pens per feeder) and 6 feeders per treatment. Increasing dietary Lys increased (quadratic, P < 0.02) ADG and G:F with the greatest response observed as SID Lys increased from 1.22 to 1.32% and, then, slight improvements with 1.42 and 1.52% during d 0 to 14. In Exp. 4, 770 pigs (7.4 kg BW) were used with 22 pigs per pen and 7 pens per treatment. Increasing SID Lys increased (quadratic, P = 0.05) ADG with pigs fed 1.32 and 1.42% SID Lys diets having the greatest BW gains during d 0 to 14. Increased SID Lys decreased (linear, P < 0.001) ADFI and increased (linear, P < 0.001; quadratic, P = 0.02) G:F. In conclusion, results of these experiments indicate that the 1998 NRC Lys recommendations (e.g., 1.19% SID Lys for 5 to 10 kg pigs) are less than required for optimal growth for 7 to 14 kg pigs. One-slope straight broken-line analysis indicated that the SID Lys requirement for optimal growth was at least 1.30% for ADG and 1.37% for G:F, or at least 3.86 and 4.18 g SID Lys/Mcal ME, respectively. Quadratic broken-line analysis indicated that the SID Lys requirement for optimal growth was at least 1.37% for ADG and 1.54% for G:F, or at least 4.19 and 4.92 g SID Lys/Mcal ME, respectively.

The effect of corn distiller's dried grains with solubles, ractopamine, and conjugated linoleic acid on the carcass performance, meat quality, and shelf-life characteristics of fresh pork following three different storage methods.

The objective of this study was to evaluate dietary corn distiller's dried grains with solubles (DDGS), ractopamine hydrochloride (RAC), and conjugated linoleic acid (CLA) on growth performance, carcass and fat quality, and shelf-life of fresh pork from finishing pigs. Barrows (n=72) were fed one of eight treatments consisting of two diet sources (corn-soy and corn-soy+20% DDGS), two levels of RAC (0 and 7.4ppm), and two levels of CLA (0 and 0.6%) for 28days. Loins were portioned (n=3) into one of three storage conditions (fresh, cold, frozen); each followed with seven days of retail display. Feeding RAC improved ADG and G:F (P<0.05), whereas DDGS decreased belly fat firmness (P<0.05). Dietary DDGS increased total polyunsaturated fatty acids in jowl and belly samples and increased Iodine Value (IV) (P<0.05), but addition of CLA decreased IV. Dietary DDGS, RAC, or CLA had minimal impact on pork quality following varied storage methods.

Impact of dietary energy level and ractopamine on growth performance, carcass characteristics, and meat quality of finishing pigs.

A total of 54 finishing barrows (initial BW = 99.8 ± 5.1 kg; PIC C22 × 337) reared in individual pens were allotted to 1 of 6 dietary treatments in a 2 × 3 factorial arrangement of treatments with 2 levels of ractopamine (0 and 7.4 mg/kg) and 3 levels of dietary energy (high, 3,537; medium, 3,369; and low, 3,317 kcal of ME/kg) to determine the effects of dietary ractopamine and various energy levels on growth performance, carcass characteristics, and meat quality of finishing pigs. High-energy diets were corn-soybean-meal-based with 4% added fat; medium-energy diets were corn-soybean meal based with 0.5% added fat; and low-energy diets were corn-soybean meal based with 0.5% added fat and 15% wheat middlings. Diets within each ractopamine level were formulated to contain the same standardized ileal digestible Lys:ME (0 mg/kg, 1.82; and 7.4 mg/kg, 2.65 g/Mcal of ME). Individual pig BW and feed disappearance were recorded at the beginning and conclusion (d 21) of the study. On d 21, pigs were slaughtered for determination of carcass characteristics and meat quality. No ractopamine × energy level interactions (P > 0.10) were observed for any response criteria. Final BW (125.2 vs. 121.1 kg), ADG (1.2 vs. 1.0 kg/d), and G:F (0.31 vs. 0.40) were improved (P < 0.001) with feeding of ractopamine diets. Feeding of the low-energy diet reduced (P = 0.001) final BW and ADG compared with the high- and medium-energy diets. Gain:feed was reduced (P = 0.005) when the medium-energy diets were fed compared with the high-energy diets. Additionally, G:F was reduced (P = 0.002) when the low-energy diets were compared with the high- and medium-energy diets. Feeding ractopamine diets increased (P < 0.05) HCW (93.6 vs. 89.9 kg) and LM area (51.2 vs. 44.2 cm(2)). The LM pH decline was reduced (P ≤ 0.05) by feeding ractopamine diets. The feeding of low-energy diets reduced (P = 0.001) HCW when compared with the high- and medium-energy diets and reduced (P = 0.024) 10th-rib backfat when compared with the high- and medium-energy diet. These data indicate that feeding ractopamine diets improved growth performance and carcass characteristics, while having little or no detrimental effect on meat quality. Reductions in energy content of the diet by adding 15% wheat middlings resulted in impaired ADG, G:F, and 10th-rib backfat. There were no ractopamine × energy level interactions in this trial, which indicates that the improvements resulting from feeding ractopamine were present regardless of the dietary energy levels.

Fatty acid profiles and iodine value correlations between 4 carcass fat depots from pigs fed varied combinations of ractopamine and energy.

A total of 54 finishing barrows (initial BW = 99.8 ± 5.1 kg; PIC C22 × 337) reared in individual pens were allotted to 1 of 6 dietary treatments in a 2 × 3 factorial arrangement of treatments with 2 levels of ractopamine (0 and 7.4 mg/kg) and 3 levels of dietary energy (high: 3,537, medium: 3,369, and low: 3,317 kcal/kg of ME) to determine the effects of feeding ractopamine and various dietary energy levels on the fatty acid profile of 4 carcass fat depots (jowl, belly, subcutaneous loin, and intramuscular) and the predictive relationships of calculated iodine value (IV) between these 4 fat depots. Carcasses were sampled for fat tissues at the anterior tip of the jowl, posterior to the sternum on the belly edge, three-quarters the distance around the LM (subcutaneous fat; SC), and within the LM (intramuscular fat; IMF). Feeding ractopamine diets reduced (P < 0.05) total SFA in SC and IMF and increased (P = 0.04) total MUFA in SC. Also, feeding ractopamine diets increased (P < 0.01) the IV of IMF. Total MUFA of belly fat was reduced (P < 0.05) when the low-energy diet was fed compared with the high-energy diet. Jowl fat total MUFA was reduced (P < 0.05) and total PUFA was increased (P < 0.05) when the medium-energy diet was fed compared with the high- and low-energy diets. Iodine values, independent of treatment, were 60.97, 64.51, 55.59, and 58.26 for belly, jowl, IMF, and SC fat depots, respectively. The IV correlations within fat depots were not consistent across dietary treatments because of the effect of treatments on carcass fatty acid characteristics. Feeding ractopamine diets shifted the fatty acid profile from SFA to MUFA in the SC depot. Feeding ractopamine diets did not change belly fat profiles, thus avoiding the potential negative effect of softening belly fat, which is detrimental to processing value. The IV of one fat depot may not be a good indication of IV of other fat depots because of weak correlation coefficients and the apparent influence of dietary treatment.

Net energy of soybean oil and choice white grease in diets fed to growing and finishing pigs.

The objectives of this experiment were 1) to determine the NE of soybean oil (SBO) and choice white grease (CWG) fed to growing and finishing pigs, 2) to evaluate the effects of inclusion rate of SBO on the NE by growing and finishing pigs, and 3) to determine if there is a difference in the NE of SBO and CWG between growing and finishing pigs. Forty-eight growing (initial BW: 22.13 ± 1.78 kg) and 48 finishing (initial BW: 84.17 ± 5.80 kg) barrows were used, and they were housed and fed individually. Within each stage of growth, pigs were allotted to 8 outcome groups of 6 barrows based on BW. Within each outcome group, pigs were randomly allotted to 1 of 6 groups. Two groups at each stage of growth served as an initial slaughter group. Pigs in the remaining groups were assigned to 4 dietary treatments and slaughtered at the conclusion of the experiment. The basal diet contained corn, soybean meal, and no supplemental lipids. Three additional diets were formulated by mixing 95% of the basal diet and 5% SBO, 90% of the basal diet and 10% SBO, or 90% of the basal diet and 10% CWG. Average daily gain and G:F for finishing pigs and apparent total tract digestibility of energy for growing and finishing pigs increased (linear, P < 0.05) with lipid content, but was not affected by lipid source. The lipid gain:protein gain ratio and the energy retention also increased (linear, P ≤ 0.05) with lipid content in growing and finishing pigs. There were no interactive effects between lipid content and stage of growth or between lipid source and stage of growth on the NE of diets and the NE of dietary lipids. The NE of diets increased (linear, P < 0.01) with increasing SBO (2,056, 2,206, and 2,318 kcal/kg for diets containing 0, 5, or 10% SBO). The NE of the diet containing 10% CWG (2,440 kcal/kg) was greater (P < 0.05) than the NE of the diet containing 10% SBO. The NE of diets was greater (P < 0.05) for finishing pigs than for growing pigs regardless of lipid content or source. The NE of SBO included at 5% (5,073 kcal/kg) was not different from the NE of SBO included at 10% (4,679 kcal/kg), but the NE of CWG (5,900 kcal/kg) was greater (P < 0.05) than the NE of SBO. The stage of growth had no impact on the NE of SBO or CWG. In conclusion, the NE of lipids is not affected by the content of dietary lipids, but the NE of CWG is greater than the NE of SBO.

Estimation of the standardized ileal digestible valine-to-lysine ratio in 13- to 32-kilogram pigs.

Three experiments were conducted to determine the optimum standardized ileal digestible Val-to-Lys (SID Val:Lys) ratio for 13- to 32-kg pigs. In Exp. 1, 162 pigs weaned at 17 d of age (8 pens/treatment) were used, and a Val-deficient basal diet containing 0.60% l-Lys·HCl, 1.21% SID Lys, and 0.68% SID Val was developed (0.56 SID Val:Lys). Performance of pigs fed the basal diet was inferior to a corn-soybean meal control containing only 0.06% l-Lys·HCl, but was fully restored with the addition of 0.146% l-Val to the basal diet (68% SID Val:Lys). In Exp. 2, 54 individually housed barrows (21.4 kg) were utilized in a 14-d growth assay. Pigs were offered a similar basal diet (1.10% SID Lys), ensuring Lys was marginally limiting with no supplemental l-Val (55% SID Val:Lys). The basal diet was fortified with 4 graded levels of l-Val (0.055% increments) up to a ratio of 75% SID Val:Lys. In Exp. 3, 147 barrows (13.5 kg) were fed identical diets, only with 1 additional level at a SID Val:Lys of 80% and fed for 21 d. In Exp. 2 and 3, a high protein, control diet was formulated to contain 1.10% SID Lys and 0.20% l-Lys·HCl. In Exp. 2, linear effects on ADG (713, 750, 800, 796, and 785 g/d; P = 0.05) and G:F (P = 0.07) were observed with increasing SID Val:Lys, characterized by improvements to a ratio of 65% and a plateau thereafter. In Exp. 3, quadratic improvements in ADG (600, 629, 652, 641, 630, and 642 g/d; P = 0.08) and G:F (P = 0.07) were observed with increasing SID Val:Lys, as performance increased to a ratio of 65% but no further improvement to a ratio of 80%. Pigs fed the control diet did not differ from those fed a ratio of 65% SID Val:Lys in Exp. 2, but did have improved G:F in Exp. 3 (P = 0.03). To provide a more accurate estimate of the optimum SID Val:Lys, data from Exp. 2 and 3 were combined. With single-slope broken-line methodology, the minimum ratio estimate was 64 and 65% SID Val:Lys for ADG and G:F, respectively. With combined requirement estimates, the data indicate that a SID Val:Lys of 65% seems adequate in maintaining performance for pigs from 13 to 32 kg.

Fresh meat and further processing characteristics of ham muscles from finishing pigs fed ractopamine hydrochloride.

Ractopamine hydrochloride (RAC) has consistently led to an advantage in carcass cutting yields of finishing pigs and remains a common feed additive in US finishing pig diets. Less is known about the effect of RAC on further processing characteristics. Some researchers have reported advantages in ultimate pH of the LM in pigs fed RAC. If a greater ultimate pH was also observed in hams, the increased pH could affect further processing characteristics and lead to better protein interaction and improved textural properties. The objective of this experiment was to determine if RAC-fed pigs yielded hams with a greater ultimate pH, and if so, whether or not that advantage improves textural properties and water retention of further processed hams. Two hundred hams from barrows and gilts fed RAC or control diets were selected based on HCW. Hams were fabricated into 5 separate pieces to determine cutting yields, and 6 muscles were evaluated for ultimate pH. Hams were processed to make cured and smoked hams. Ractopamine increased cutting yields of the whole ham (P < 0.0001), inside (P < 0.01), outside (P < 0.01), and knuckle (P < 0.01) when expressed as a percentage of chilled side weight. Ultimate pH of the rectus femoris, vastus lateralis, and semitendinosus were all 0.06 pH units greater (P < 0.05), the biceps femoris was 0.04 pH units greater (P = 0.02), and the semimembranosus and adductor muscles were 0.03 pH units greater in pigs fed 7.4 mg/kg of RAC when compared with control pigs. Cured hams from RAC-fed pigs were heavier at all stages of production. No differences were detected in binding strengths (P = 0.88) or protein fat-free values (P = 0.13) between RAC (9.06 kg and 20.37) and control hams (9.01 kg and 20.13). Ractopamine increased cutting yields, total weight of cured hams, and ultimate muscle pH. Ractopamine can be fed to pigs to achieve the desired growth characteristic advantages and cutting yields without affecting further processed ham characteristics.

Amino acid digestibility and energy concentration in a novel source of high-protein distillers dried grains and their effects on growth performance of pigs.

Three experiments were conducted to evaluate a novel source of high-protein distillers dried grains produced by Buhler Inc. (HP-DDG(Buhler)) and fed to growing pigs. The standardized ileal digestibility (SID) of AA in HP-DDG(Buhler) and in soybean meal (SBM) was determined in Exp. 1. Nine pigs (109.8 +/- 2.78 kg of BW) were fitted with a T-cannula in the distal ileum and allotted to a triplicated 3 x 3 Latin square design with 3 diets and 3 periods per square. Diets containing HP-DDG(Buhler) or SBM as the only source of AA and an N-free diet were formulated. The SID of indispensable AA was less (P < 0.01) in HP-DDG(Buhler) than in SBM (Arg, 87.5 vs. 93.9%; His, 76.7 vs. 88.7%; Ile, 76.4 vs. 87.5%; Leu, 77.8 vs. 86.8%; Lys, 75.4 vs. 88.4%; Met, 82.8 vs. 88.4%; Phe, 77.9 vs. 87.3%; Thr, 72.5 vs. 83.5%; Trp, 85.1 vs. 91.0%; Val, 73.3 vs. 84.3%). The DE and ME in HP-DDG(Buhler) and in corn were measured in Exp. 2 using 16 growing barrows (24.6 +/- 1.66 kg of BW). A corn-based diet and a diet containing 50% corn and 48.2% HP-DDG(Buhler) were formulated. The total collection method and the difference procedures were used. The concentrations of DE and ME in HP-DDG(Buhler) were greater (P < 0.001) than in corn (5,043 vs. 4,002 kcal/kg of DM and 4,690 vs. 3,921 kcal/kg of DM, respectively). Experiment 3 was a 9-wk growth assay using 40 pigs (initial BW: 58.2 +/- 2.28 kg) allotted to 5 dietary treatments, with 8 replicates of individually housed pigs per treatment. Treatments included a control diet based on corn and SBM and 4 diets in which HP-DDG(Buhler) replaced 33, 66, 66, or 100% of the SBM in the control diet. All HP-DDG(Buhler) diets contained supplemental Lys and Thr to provide similar concentrations of SID Lys and Thr in all diets; one of the diets in which HP-DDG(Buhler) replaced 66% of the SBM and the diet in which HP-DDG(Buhler) replaced 100% of the SBM also contained crystalline Trp. Dietary treatments had no effect on ADG (1.15, 1.13, 1.16, 1.12, and 1.14 kg), ADFI (3.33, 3.35, 3.39, 3.30, and 3.33 kg), or G:F (0.35, 0.34, 0.34, 0.34, and 0.34 kg/kg). Carcass traits of pigs fed the diet in which HP-DDG(Buhler) replaced 100% of the SBM were not different from those of pigs fed the control diet. In conclusion, HP-DDG(Buhler) contains more DE and ME than corn, but has decreased SID values for AA compared with SBM. Soybean meal can be replaced by HP-DDG(Buhler) in diets fed to finishing pigs without any effect on growth performance or carcass characteristics, provided that diets are adequate in indispensable AA.